PIAGGIO X9 Manual Para Talleres De Servicio página 205

Predelivery operations
Predelivery checks:
Appearance
• Paintwork
• Mating of plastics
• Scratches
•Dirt
Fastenings
• Safety tightening torques
• Fixing screws
Electrical equipment
• Master switch
• Lights: high beam, low beam, parking lights and
related warning lights
• Headlight adjustment according to regulations
in force
• Rear light, parking light, brake light
• Front and rear brake light switches
• Turn indicators and related warning lights
• Instrument panel light
• Instruments: fuel gauge and temperature indi-
cator
• Instrument panel warning lights
•Horn
• Starting device
• Set instruments to miles/mph
Levels
• Hydraulic braking system fluid level
• Rear hub oil level
• Engine coolant level
Road test
• Operation of immobilizer
• Cold starting
• Operation of instruments
• Operation of throttle control
• Stability during acceleration and braking
• Operation of front and rear brakes
• Operation of front and rear suspensions
• Abnormal noise
Static test after road test
• Hot restarting
• Operation of starting device
• Idle speed stability (when turning handlebar)
• Steering smooth rotation
• Leakages
Functional test
• Hydraulic braking
system
• Mechanical braking
system
• Clutch
• Engine
• Other
9 - 4 1 st Update to part no. 594599 X9 125-180 cc 4T 4V
Primera actualización dib. 594599 X9 125-180 cc 4T 4V
8
1 Atualização Des. 594599 X9 125-180 cc 4T 4V
lever travel
lever travel
check operation
check throttle control
travel
check papers
check frame and
engine numbers
check tool kit
fit number plate
check locks
check tyre pressures
fit mirrors and any
accessories
/arning . jo ensure maximum performance, the
battery must be charged before use. Inadequate charg-
ing of the battery before it is first used with a low level of
the electrolyte shortens the life of the battery.
Caution
| - Before charging the battery, remove the
plug from each cell.
Keep open flames and sparks away from the battery
during recharging.
When removing the battery from the vehicle, disconnect
the negative cable first.
Warning - When installing the battery, connect the
positive cable and then the negative cable.
Caution
| - The battery electrolyte is poisonous and
causes severe burns as it contains sulphuric acid. Avoid
contact with the eyes, the skin and clothing.
In case of contact with the eyes or the skin, rinse
generously with water for about 15 minutes and imme-
diately seek medical attention.
In case of ingestion, immediately drink lar.ge quantities
of water or vegetable oil. Immediately seek medical
attention.
Batteries produce explosive gases. Keep them away
from open flames, sparks and cigarettes. If the battery
is charged in a closed place, take care to ensure
adequate ventilation.
Always protect the eyes when working close to batter-
ies.
KEEP OUT OF REACH OF CHILDREN
Warning - Never use fuses having a higher rating
than recommended. Using a fuse of unsuitable rating
may seriously damage the vehicle or even cause a fire.
Warning - Check the inflating pressures when the
tyres are at ambient temperature.
Warning - Do not exceed the recommended inflating
pressures as the tyres may burst.
Safety tightening torques:
X9 125-180 ce 4T4V