Watts Premier RO-PURE Manual De Instalación, Operación Y Mantenimiento

Installation, Operation
and Maintenance Manual
4-Stage Reverse Osmosis Systems
Model RO-PURE
WARNING
!
Read this Manual BEFORE using this equipment.
Failure to read and follow all safety and use information
can result in death, serious personal injury, property
damage, or damage to the equipment.
Keep this Manual for future reference.
! WARNING
Do not use with water that is microbiologically unsafe or of
unknown quality without adequate disinfection before or after
the system.
WARNING
!
Discard small parts remaining after the installation.
NOTICE
If you are unsure about installing this product, consult a
professional plumber or call a WATTS representative.
Failure to follow instructions and install correctly may result in
leaks, property damage and/or product not performing correctly,
and voids warranty.
Handle all system parts and components carefully. Do not drop,
drag, or turn components upside down.
Be sure floor under the system is clean, level and strong enough
to support the unit, and that the Module is mounted to a surface
strong enough to support its weight.
System tested and certified by WQA against
NSF/ANSI Standard 58 for the reduction of the
claims specified on the performance data sheet
and to NSF/ANSI 372 for lead free compliance.
Table of Contents
Introduction. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Before Installation
Operational Parameters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Contents of Under Counter Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
System Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-3
Tools Recommended For Installation . . . . . . . . . . . . . . . . . . . . . . . . 4
Using Quick-Connect Fittings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Installation
Step 1. Adapt-A-Valve™ Installation . . . . . . . . . . . . . . . . . . . . . . . . . 4
Step 2. Drill a Hole for the Faucet in a Sink . . . . . . . . . . . . . . . . . . . . 5
Step 3. Watts Top Mount Faucet Installation . . . . . . . . . . . . . . . . . . . 5
Step 4. Blue Tube from Faucet to RO Module . . . . . . . . . . . . . . . . . . 6
Step 5. Red Tube from Faucet to RO Module . . . . . . . . . . . . . . . . . . 6
Step 6. Reverse Osmosis Module Mounting . . . . . . . . . . . . . . . . . . . 6
Step 7. Drain Saddle Installation . . . . . . . . . . . . . . . . . . . . . . . . . . 6-7
Step 8. Green Tube Connection . . . . . . . . . . . . . . . . . . . . . . . . . . . ..7
Step 9. Tank Ball Valve Installation . . . . . . . . . . . . . . . . . . . . . . . . . . ..7
Step 10. Blue Tube Connection to Tank .. . . . . . . . . . . . . . . . . . . . . ..7
Step 11. Ice maker Connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Operation
Startup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Maintenance
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8-9
Membrane Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Annual Sanitization . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Check Air Pressure in the Tank . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Procedure for Extended Non-Use (More than 2 months) . . . . . . . . . . 9
Technical & Warranty Information
Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Performance Data Sheet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11-12
Arsenic Facts. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Service Record . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Limited Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
IOM-Premier-RO-Pure
RO-PURE
Pages
®